The Dyer's Guide
Being a Compendium of the Art of Dyeing
Linen, Cotton, Silk, Wool, Muslin, Dresses, Furniture, &c. &c.
With The Method of
Scouring Wool, Bleaching Cotton, &c.
And
Directions for Ungumming Silk, And For Whitening And Sulphuring Silk And Wool.
And Also
An Inttroductory Epitome of The Leading Facts in Chemistry, As Connected With The Art of Dyeing.
By Thomas Packer,
Dyer and Practical Chemist.
"Cet arte est un des plus utiles et des plus merveilleux qu'on connoisse."
- Chaptal.
"There is no art which depends so much on chemistry as dyeing."
- Garnett.
Second Edition,
Corrected and Materially Improved.
London:
Printed for Sherwood, Gilbert, And Piper,
Paternoster-Row.
1830.
Take, upon as small a scale as can conveniently be tried, a copper vessel, which will contain about twelve gallons, two thirds full of soft water, and one ounce of madder. Fix this small copper in a larger copper of water, so that the heat may be applied to keep the liquor in the smaller copper at a proper temperature; it will be then, in fact, a water bath.
Having kindled the fire in the afternoon, put in a good handful of bran and five pounds of woad; at five o'clock in the evening let it be well stirred and covered over, the liquor being about blood-warm; let the same heat be continued as nearly as possible, at least so as not to be lower than summer heat by the thermometer, nor higher than ferer heat by the same instrument. The vat must again be well stirred at seven, at nine, at twelve at night, at two in the morning, and at four.
Hellot, describing this process, observes, that "the woad then working, some air bubbles began to rise pretty large, but few in number, and of a very faint colour; it had then two ounces of lime added, and was stirred; this was four o'clock in the morning; at five a pattern was put in, and at six it was taken out and the vat stirred. This pattern had received some colour. At seven o'clock another pattern was put in, and at eight it was stirred again. The second pattern was tolerably bright. An ounce of prepared indigo, (see p. 75.) was then added; at nine o'clock another pattern was put in; at ten it was stirred again, taking the pattern out, and putting in an ounce of lime because it began to smell sweetish; at eleven another pattern; at twelve at noon it was stirred again. This process was continued till five o'clock in the evening; then were added three ounces of prepared indigo; at six another pattern was tried, and at seven it was stirred again; the last pattern came out of a very good green, and became a bright blue. One ounce of lime was added to sustain it till nine o'clock the next morning; patterns were put in from time to time: the last was very beautiful. The vat was then filled up with water and a small quantity of bran and stirred; after which patterns were tried every hour till five o'clock in the evening, when, being in a proper state, it was immediately worked. Some time was then added to preserve it; it was stirred and left to another opportunity to reheat."
Ei kommentteja :
Lähetä kommentti